CONFIRMED FIXES FOR DODGE TRUCKS
Item# confirmed-fixes-for-dodge-trucks

Product Description

Description Potential Causes Confirmed Fix 1. Engine cranks, but is a no start. No spark and no fuel injector pulse. The odometer reads No Bus intermittently. No scan tool communication.... 2002 Dodge Ram 1500 Pickup 5.9L, Vin Z, Eng Cfg V8 Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Check for 5 volts on the Orange wire at the Crank Position Sensor (CKP) and on the Violet/White wire to the transmission 8-pin connector. 2. If not 5 volts, check for B+ on the Light Green/Bla...

9 Confirmed fixes Cam Angle (CMP) Sensor Crank Angle Sensor (CKP) Governor Pressure Sensor Manifold Absolute Pressure (MAP) Sensor Powertrain Control Module (PCM) Throttle Position Sensor (TPS) Wiring 8 - Powertrain Control Module (PCM) 1 - Crankshaft Position (CKP) Sensor Harness

2. One cylinder gets loaded with fuel. Swapping a fuel injector did not help. No trouble codes stored. The purge solenoid, fuel pump relay and Automatic Shut Down (ASD) relay start clicking at key on.... 2002 Dodge Ram 1500 Pickup 5.9L, Vin Z, Eng Cfg V8 Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Check the power and grounds for the Powertrain Control Module (PCM). 2. If the powers and grounds are OK, replace the PCM. 3. Enter the Vehicle Identification Number (VIN) into the new PCM....

3 Confirmed fixes Powertrain Control Module (PCM) Wiring Harness 3 - Powertrain Control Module (PCM)

3. Trouble code P1391-intermittent loss of cam and crank. Cannot find out what is causing it.... 2002 Dodge Ram 1500 Pickup 5.9L, Vin Z, Eng Cfg V8 Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Check the Crankshaft Position (CKP) and Camshaft Position (CMP) sensor signals and sync. Using a dual trace lab scope, check both the CKP and CMP sensor signals and make sure that sync is good all...

3 Confirmed fixes Camshaft Position Sensor (CMP) Crankshaft Position (CKP) Sensor Flex Plate Timing Chain Wiring 3 - Crankshaft Position (CKP) Sensor

4. Keeps getting gas in the oil.... 2002 Dodge Ram 1500 Pickup 5.9L, Vin Z, Eng Cfg V8 Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Check fuel pressure, should be 49 PSI, check for leaky fuel injectors....

2 Confirmed fixes Fuel Injectors Fuel Pump Module Assembly 1 - Fuel Pump Module Assembly 1 - Oil Level

5. No crank, no communication with the Scan Tool.... 2002 Dodge Ram 1500 Pickup 5.9L, Vin Z, Eng Cfg V8 Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Check the 5v power supply at the Powertrain Control Module (PCM). 2. Check the powers and grounds at the PCM. 3. The 5 volt supply is from pin 17 of C1 and pin 31 of C2. 4. These ...

2 Confirmed fixes A/C Pressure Transducer Cam Angle (CMP) Sensor Crank Angle Sensor (CKP) Governor Pressure Sensor Manifold Absolute Pressure (MAP) Sensor Powertrain Control Module (PCM) Throttle Position Sensor (TPS) Wiring 1 - Powertrain Control Module (PCM) 1 - Wiring

6. Engine cranks, but is a no start. No spark and no fuel injector pulse. The odometer reads No Bus intermittently. No scan tool communication.... 2002 Dodge Ram 1500 Pickup 5.9L, Vin Z, Eng Cfg V8 Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Check for 5 volts on the Orange wire at the Crank Position Sensor (CKP) and on the Violet/White wire to the transmission 8-pin connector. 2. If not 5 volts, check for B+ on the Light Green/Bla...

1 Confirmed fix Cam Angle (CMP) Sensor Crank Angle Sensor (CKP) Governor Pressure Sensor Manifold Absolute Pressure (MAP) Sensor Powertrain Control Module (PCM) Throttle Position Sensor (TPS) Wiring 1 - Powertrain Control Module (PCM)

7. Engine stalls randomly while driving, like shutting off the key, then it restarts right away. No codes.... 2002 Dodge Ram 1500 Pickup 5.9L, Vin Z, Eng Cfg V8 Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Monitor the Crankshaft Position Sensor (CKP) and the Camshaft Position Sensor (CMP) signals. 2. Monitor the Powertrain Control Module (PCM) power and ground supplies and 5 volt power supplies....

1 Confirmed fix Camshaft Position Sensor (CMP) Crankshaft Position (CKP) Sensor Powertrain Control Module (PCM) Wiring 1 - Powertrain Control Module (PCM)

8. Cranks no start, has spark and injector pulse and fuel pressure.... 2002 Dodge Ram 1500 Pickup 5.9L, Vin Z, Eng Cfg V8 Test Details... Confirmed Fix Details...

Tests/Procedures: 1. See if the engine will start if the fuel pump relay is removed and then spraying carburetor spray into the throttle body while cranking. 2. If it does, drain the fuel tank and try fresh fuel....

1 Confirmed fix Fuel Contamination 1 - Fuel (Gasoline)

9. Cranks no start, it has a code P0351.... 2002 Dodge Ram 3500 Van 5.9L, GAS, Vin Z * Test Details... Confirmed Fix Details...

Tests/Procedures: 1. With a compatible scan tool, run the Actuator Tests (ATM) of the coil. 2. Check the voltage on the Dark Green/Orange wire at the coil connector. It should be battery voltage. 3. The Black/G...

17 Confirmed fixes Coil Powertrain Control Module (PCM) Wiring Harness 13 - Powertrain Control Module (PCM) 2 - Ignition Coil 1 - Automatic Shutdown (ASD) Relay, Ignition Coil 1 - Ignition Coil Wiring

10. No spark, cam/crank sensor signals look good.... 2002 Dodge Ram 2500 Pickup 5.9L, GAS, Vin Z, Eng Cfg V8 * Test Details... Confirmed Fix Details...

Tests/Procedures: 1. With a compatible scan tool, run the Actuator Tests (ATM) of the coil. 2. Check the voltage on the Dark Green/Orange wire at the coil connector. It should be battery voltage. 3. The Blac...

12 Confirmed fixes Coil Powertrain Control Module (PCM) Wiring 8 - Ignition Coil 4 - Powertrain Control Module (PCM) Description Potential Causes Confirmed Fix 1. Speedometer is not working. Code P0500 is stored in the Powertrain Control Module (PCM). Tried a new speed sensor already. Vehicle is not equipped with ABS brakes.... 2005 Jeep Liberty Sport 3.7L, GAS, Vin K, Eng Cfg V6 * Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Test the speedometer operation in the manual self-test mode. Test by starting with the key "off". Hold the trip reset button down while turning the key to the "on" position. All the gauges should ...

10 Confirmed fixes Body Control Module (BCM) Speed Sensor Speedometer Wiring 2 - Rear Differential Speed Sensor Wiring 1 - Body Control Module (BCM) 1 - Differential Fluid, Differential Speed Sensor (DSS) 1 - Differential Speed Sensor (DSS) 1 - Rear Wheel Speed Sensor (WSS), Rear Wheel Speed Sensor (WSS) Connector 1 - Rear Wheel Speed Sensor (WSS) 1 - Rear Wheel Speed Sensor Wiring 1 - Wiring 1 - Wiring Harness

2. Speedometer is not working. Code P0500 is stored in the Powertrain Control Module (PCM). Tried a new speed sensor already. Vehicle is not equipped with ABS brakes.... 2005 Jeep Liberty Limited 3.7L, GAS, Vin K, Eng Cfg V6 * Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Test the speedometer operation in the manual self-test mode. Test by starting with the key "off". Hold the trip reset button down while turning the key to the "on" position. All the gauges should ...

2 Confirmed fixes Body Control Module (BCM) Speed Sensor Speedometer Wiring 1 - Differential Speed Sensor (DSS) 1 - Speedometer Head

3. Cluster, wipers, horn and dash lights are inoperative, has many codes.... 2006 Dodge Dakota Slt 3.7L, Vin K, Eng Cfg V6 * Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Check the connector at the cluster to verify that it is fully seated....

2 Confirmed fixes Instrument Cluster Connector 1 - Ignition Switch 1 - Instrument Cluster Connector

4. Dash lights are flickering at times.... 2005 Jeep Grand Cherokee Laredo 3.7L, Vin K, Eng Cfg V6 * Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Look into TSB# 08-016-07. The bulleting involves replacing the Body Control Module (BCM) for a flickering dash light problem. 2. Check the powers and grounds to the BCM....

1 Confirmed fix Body Control Module (BCM) Wiring Harness 1 - Ignition Switch

5. Dash lights are flickering at times.... 2006 Jeep Liberty Sport 3.7L, GAS, Vin K, Eng Cfg V6 * Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Look into TSB# 08-016-07. The bulleting involves replacing the Body Control Module (BCM) for a flickering dash light problem....

1 Confirmed fix Body Control Module (BCM) 1 - Body Control Module (BCM)

6. Vehicle has been hit by lightning. Many of the modules on the vehicle have been replaced. The dash lighting is not working, turn signal indicators are not working. Dome light is not working. Unable t... 2005 Dodge Ram 1500 3.7L, GAS, Vin K, Eng Cfg V6 * Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Try running the cluster self test. Start with the key off. Hold down the trip reset button, then at the same time turn the key "on". Once the dash lights up, the button can be released. Check the ...

1 Confirmed fix Instrument Cluster 1 - Instrument Cluster

7. Fuel gauge is stuck on 3/4. Tried two new fuel pump assemblies.... 2006 Jeep Liberty Sport 3.7L, GAS, Vin K, Eng Cfg V6 * Test Details...

Tests/Procedures: 1. Run the self test on the instrument cluster to see if the gauge moves during the sweep test. If the gauge does not move the cluster has failed. Start with the key "off". hold down the trip reset b... Instrument Cluster

8. Customer complaint of dash going dead in raining weather. It hasn't acted up in the shop.... 2005 Jeep Grand Cherokee Laredo 3.7L, Vin K, Eng Cfg V6 * Test Details...

Tests/Procedures: 1. Try misting the area in and around the Integrated Power Module (IPM), pull the Front Control Module (FCM) off of the module and see if there are any signs of corrosion or moisture.... FCM Instrument Panel Module (IPM) Integrated Power Module (IPM) Wiring

9. The tire went low and the pressure monitor light came on and won't go out after the tire repair.... 2005 Jeep Liberty Limited 3.7L, GAS, Vin K, Eng Cfg V6 * Test Details...

Tests/Procedures: 1. Retrain the Sentry Key RemotE Entry Module (Skreem). 2. Park the vehicle for at least 15 minutes, then drive the vehicle a minimum of 5 minutes continually above 13 MPH.... Information Only



- Confirmed Fix - Exact Vehicle Match - Confirmed Fix - Similar Vehicle Match * - A vehicle with the same engine as the one you selected, plus or minus two years. Description Potential Causes Confirmed Fix 1. Speedometer is not working. Code P0500 is stored in the Powertrain Control Module (PCM). Tried a new speed sensor already. Vehicle is not equipped with ABS brakes.... 2005 Jeep Liberty Sport 3.7L, GAS, Vin K, Eng Cfg V6 * Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Test the speedometer operation in the manual self-test mode. Test by starting with the key "off". Hold the trip reset button down while turning the key to the "on" position. All the gauges should ...

10 Confirmed fixes Body Control Module (BCM) Speed Sensor Speedometer Wiring 2 - Rear Differential Speed Sensor Wiring 1 - Body Control Module (BCM) 1 - Differential Fluid, Differential Speed Sensor (DSS) 1 - Differential Speed Sensor (DSS) 1 - Rear Wheel Speed Sensor (WSS), Rear Wheel Speed Sensor (WSS) Connector 1 - Rear Wheel Speed Sensor (WSS) 1 - Rear Wheel Speed Sensor Wiring 1 - Wiring 1 - Wiring Harness

2. Speedometer is not working. Code P0500 is stored in the Powertrain Control Module (PCM). Tried a new speed sensor already. Vehicle is not equipped with ABS brakes.... 2005 Jeep Liberty Limited 3.7L, GAS, Vin K, Eng Cfg V6 * Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Test the speedometer operation in the manual self-test mode. Test by starting with the key "off". Hold the trip reset button down while turning the key to the "on" position. All the gauges should ...

2 Confirmed fixes Body Control Module (BCM) Speed Sensor Speedometer Wiring 1 - Differential Speed Sensor (DSS) 1 - Speedometer Head

3. Cluster, wipers, horn and dash lights are inoperative, has many codes.... 2006 Dodge Dakota Slt 3.7L, Vin K, Eng Cfg V6 * Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Check the connector at the cluster to verify that it is fully seated....

2 Confirmed fixes Instrument Cluster Connector 1 - Ignition Switch 1 - Instrument Cluster Connector

4. Dash lights are flickering at times.... 2005 Jeep Grand Cherokee Laredo 3.7L, Vin K, Eng Cfg V6 * Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Look into TSB# 08-016-07. The bulleting involves replacing the Body Control Module (BCM) for a flickering dash light problem. 2. Check the powers and grounds to the BCM....

1 Confirmed fix Body Control Module (BCM) Wiring Harness 1 - Ignition Switch

5. Dash lights are flickering at times.... 2006 Jeep Liberty Sport 3.7L, GAS, Vin K, Eng Cfg V6 * Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Look into TSB# 08-016-07. The bulleting involves replacing the Body Control Module (BCM) for a flickering dash light problem....

1 Confirmed fix Body Control Module (BCM) 1 - Body Control Module (BCM)

6. Vehicle has been hit by lightning. Many of the modules on the vehicle have been replaced. The dash lighting is not working, turn signal indicators are not working. Dome light is not working. Unable t... 2005 Dodge Ram 1500 3.7L, GAS, Vin K, Eng Cfg V6 * Test Details... Confirmed Fix Details...

Tests/Procedures: 1. Try running the cluster self test. Start with the key off. Hold down the trip reset button, then at the same time turn the key "on". Once the dash lights up, the button can be released. Check the ...

1 Confirmed fix Instrument Cluster 1 - Instrument Cluster

7. Fuel gauge is stuck on 3/4. Tried two new fuel pump assemblies.... 2006 Jeep Liberty Sport 3.7L, GAS, Vin K, Eng Cfg V6 * Test Details...

Tests/Procedures: 1. Run the self test on the instrument cluster to see if the gauge moves during the sweep test. If the gauge does not move the cluster has failed. Start with the key "off". hold down the trip reset b... Instrument Cluster

8. Customer complaint of dash going dead in raining weather. It hasn't acted up in the shop.... 2005 Jeep Grand Cherokee Laredo 3.7L, Vin K, Eng Cfg V6 * Test Details...

Tests/Procedures: 1. Try misting the area in and around the Integrated Power Module (IPM), pull the Front Control Module (FCM) off of the module and see if there are any signs of corrosion or moisture.... FCM Instrument Panel Module (IPM) Integrated Power Module (IPM) Wiring

9. The tire went low and the pressure monitor light came on and won't go out after the tire repair.... 2005 Jeep Liberty Limited 3.7L, GAS, Vin K, Eng Cfg V6 * Test Details...

Tests/Procedures: 1. Retrain the Sentry Key RemotE Entry Module (Skreem). 2. Park the vehicle for at least 15 minutes, then drive the vehicle a minimum of 5 minutes continually above 13 MPH.... Information Only



- Confirmed Fix - Exact Vehicle Match - Confirmed Fix - Similar Vehicle Match * - A vehicle with the same engine as the one you selected, plus or minus two years.

("CHANGING PARTS CAN BE EXPENSIVE TAKE THE GUESS WORK OUT IT") NOW YOU HAVE A ONLINE AUTO MECHANIC AT YOUR SIDE: FACTORY WIRING DIAGRAMS: I WILL GIVE A CONFIRMED FIX TO YOUR CAR PROBLEM IT IS WORTH THE CLICK